Calculating longitudinal shrinkage
There's no firm factor for calculating longitudinal shrinkage in maple, but here's a place to begin. 1998.
by Professor Gene Wengert
What factor should we use for calculating longitudinal shrinkage in hard maple strip flooring?
I do not have any good ideas other than to use the traditional number of 0.2% (green to dry) which amounts to about 2-1/2 inches per 100 feet. However, since the shrinkage change occurs over a 30% MC change, then we could also say that the wood will shrink longitudinally about 0.1 inches per 1% MC change per 100 feet.
The problem comes when we consider the cross grain in the wood, plus any juvenile wood, all which can shrink up to 30 times more lengthwise. I havenít seen much discussion of this lengthwise shrinkage.
Professor Gene Wengert is Extension Specialist in Wood Processing at the Department of Forestry, University of Wisconsin-Madison.
Click on Wood Doctor Archives to peruse past answers.
If you would like to obtain a copy of "The Wood Doctor's Rx", visit www.fdmbookstore.bigstep.com for more information.
The comments below were added after this Forum discussion was archived as a Knowledge Base article (add your comment).
Comment from contributor A:
The Canadian Wood Council "Introduction to Wood Design" seems to indicate a regular shrinkage coefficient of .002 and a longitudnal coefficient of .0005. p 5-17 c 1996
Would you like to add information to this article?
Interested in writing or submitting an article?
Have a question about this article?
Have you reviewed the related Knowledge Base areas below?
KnowledgeBase: Primary Processing: Yield Formulas
KnowledgeBase: Wood Engineering: Wood Properties
KnowledgeBase: Woodworking Miscellaneous: Woodworking
KnowledgeBase: Knowledge Base
All rights reserved. No part of this publication may be reproduced in
any manner without permission of the Editor.
Review Woodweb.com's Copyright Policy.
The editors, writers, and staff at Woodweb.com try to promote safe practices.
What is safe for one woodworker under certain conditions may not be safe
for others in different circumstances. Readers should undertake the use
of materials and methods discussed at Woodweb.com after considerate evaluation,
and at their own risk.
865 Troxel Road
Lansdale, PA 19446
Copyright © 1996-2021 - Woodweb.com